Tag Archive: Progeny Mk7-B

Nov 20 2020

Operations Summary – Weeks of 11/9 & 11/16/20

View post on imgur.com

View operations details »

Nov 19 2020

Progeny Mk7-B Flight 4 Analysis

With all three previous missions failing for different reasons, the fourth and final planned mission for the Mk7-B received new objectives in the hope that this mission would be successful at last. The first change was to swap out the new booster for one that had been refurbished from a previous flight, which necessitated a launch delay that pushed the date back from 10/20 to 10/29. This booster was from the second Mk7-B flight back in late August and would be the first time we attempt to re-fly an engine. On the opposite end of the rocket we swapped out the parachute nose cone for a payload fairing that encapsulated a new Luciole smallsat prototype. This would be deployed onto the sub-orbital trajectory to test its systems and reaction wheels. Recovery would be of only the first stage booster and RTG casing from the payload, which did not contain any radioactive material for this mission. Other than the delay for booster integration, no problems occurred in the lead-up to launch.

The Flight

After good retraction of the support arms at T-5s the Boostertron II solid rocket motor successfully ignited for an on-time launch at 13:45 local, pushing the rocket upwards off the pad with an initial force of 3.3Gs while the fins actuated to begin rolling the rocket from 90° towards 34°. Less than 2 seconds after launch it had spun enough to allow pitch-over to begin as well, with the flight computer guiding it along a gradual and constant change rate throughout the ascent. By L+10s the rocket had locked onto its heading and thrust from the SRB had already begun to taper off from its max 74kN to reduce loads on the rocket as it approached Mach 1.

Read the rest of this entry »

Nov 12 2020

Progeny Mk7-B Flight 3 Analysis

A pause after the first two launches was required to not only build the final two rockets but also to launch the second Ascension Mk2, which required a pad reconfiguration. The pad was setup again afterwards to support Mk7-B launches and the third rocket was trucked out to the pad to perform its mission, which we hoped would finally see the rocket on a high sub-orbital trajectory with a successful hot staging to avoid losing speed on ascent. While the launch date did not change, the rocket’s new 0.625m SRB was swapped out for a refurbished SRB to test under flight conditions for the first time after making it through two static fires.

The Flight

No delays occurred during pre-launch preparations and everything was looking good for an on-time lift off when a hold was called from the weather desk just 8 seconds prior to T-0. The mountain wave sensors were tripped and due to the high instability of the rocket without its support arms a hold had to be called before they were retracted at T-5s. No gusts were recorded at KSC in the following minutes however and after some more checking on the weather data it was determined to be a false alarm and the countdown was reset to T-2min with a new launch time of 18:00 local. The hold was released 29 minutes after it was called. T-0 arrived without further incident, all four support arms retracted properly and the Boostertron II first stage was successfully ignited to begin the ascent.

Read the rest of this entry »

Nov 06 2020

Operations Summary – Weeks of 10/26 & 11/2/20

View post on imgur.com

View operations details »

Oct 29 2020

Progeny Mk7-B Flight 4

With a final chance at mission success, objectives are changed with the addition of an actual payload to test a prototype Luciole smallsat probe and only recover the 1st stage booster, which is the same flown on the 1st flight from Aug!

View full tweet timeline »

Oct 23 2020

Operations Summary – Weeks of 10/12 & 10/19/20

View post on imgur.com

View operations details »

Oct 09 2020

Operations Summary – Weeks of 9/28 & 10/5/20

View post on imgur.com

View operations details »

Oct 06 2020

Progeny Mk7-B Flight 3

Looking for the third time to be the charm, changes are made to the early ascent to hopefully ensure mission success at last and while they seem to work ultimately we are forced to declare this yet another failure upon recovery

View full tweet timeline »

Sep 29 2020

Progeny Mk7-B Flight 2 Analysis

Hot on the heels of the first launch, the second mission was set to rectify several issues that ended up leading to a mission failure. Although the modifications needed for the rocket were made in time for an on-schedule launch the weather had other plans and forced a one day delay. Once the skies cleared up however all proceedings up to the terminal count were carried out with no additional issues.

The Flight

With the service boom swung away and the rocket on internal power and radio-frequency comms, final preparations for launch were carried out mainly by the AFCS, now in control of the rocket. 5s before booster ignition the support arms holding the rocket steady against any sudden wind gusts were retracted to clear the way for ascent and at T-0 the 0.625m dual-segment SRB lit off to push the rocket off the engine support at 13:30:00.04 local time to begin its ascent.

With an initial TWR of 3 the rocket quickly gained enough speed in the first seconds for the guidance fins to have the authority to begin pitching the rocket downrange, heading the direction it was already facing – direct east. However instead the rocket went into a slight roll and actually ended up briefly pointing back west before correcting with another roll back towards 90° however upon reaching that heading spun around again and continued to have trouble pointing itself in the proper direction to the consternation of controllers.

Read the rest of this entry »

Sep 25 2020

Operations Summary – Weeks of 9/14 & 9/21/20

View post on imgur.com

View operations details »

Older posts «